Product ID:1809 SCHOOL BUS YELLOW, INDUSTRIAL MAINT & (SUPDAT)
MSDS Date:02/01/1993
FSC:8010
NIIN:01-010-3259
MSDS Number: BWPST

SHERWIN-WILLIAMS CO

101 PROPSPECT AVE NW
CLEVELAND, OH 44115-1042
US

Emergency Phone: 216-292-7400

Info Phone: 800-247-3266

Cage: 54636

SHERWIN-WILLIAMS CO THE

CLEVELAND, OH 44115-1042 US

Telephone: 800-251-2486/216-566-2242

Cage: 54636

760

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 17%

OSHA PEL 1000 PPM

ACGIH TLV: ASPHYXIANT

22

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 20%

OSHA PEL 200 PPM

ACGIH TLV: 50 PPM, S

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

5.9

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 8%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM; 150 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

BUTYL ALCOHOL; (1-BUTANOL) (SARA 313) (CERCLA)

CAS: 71-36-3

RTECS: EO1400000

Fraction By Weight: 2%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM, S, C

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

180

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 37%

OSHA PEL 1000 PPM

ACGIH TLV: 750 PPM; 1000 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA 313) (CERCLA)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 8%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM; 300 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2-PENTANONE, 4-METHYL-; (METHYL ISOBUTYL KETONE) (SARA

CAS: 108-10-1

RTECS: SA9275000

Fraction By Weight: 3%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM; 75 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER;

CAS: 108-65-6

RTECS: AI8295000

Fraction By Weight: 60-100%

OSHA PEL N/K

ACGIH TLV: N/K

84% BY WEIGHT PER BAAQMD RULE 49

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

URINARY, BLOOD-FORM, CVS & REPRO SYS.

RTECS: 9999999ZZ

SOLVS. REPORTS HAVE ASSOC RPTD & PRLNG OVEREXP TO

RTECS: 9999999ZZ

DISPOSE OF IN ACCORDANCE WITH FEDERAL,

RTECS: 9999999ZZ

NOT SMOKE. EXTING ALL FLAMES, PILOT LIGHTS

RTECS: 9999999ZZ

& ANY OTHER SOURCES OF IGNIT. CONSULT NFPA CODE.

RTECS: 9999999ZZ

PRESS. DO NOT PUNCTURE, INCIN OR EXPOSE TO TEMPS

RTECS: 9999999ZZ

WATER & OTHER HEAT SOURCES COULD CAUSE CNTNR TO

RTECS: 9999999ZZ

DUSTS ARE LISTED, APPLIC LIMS FOR NUISANCE

RTECS: 9999999ZZ

(TDUST), 5 MG/M3 (RDUST).

RTECS: 9999999ZZ

BE GENERATED FROM THIS PROD, UNDERLYING PAINT OR

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRIT OF EYES, SKIN & RESP SYS.
MAY CAUSE NERVOUS SYS DEPRESS. EXTREME OVEREXP MAY RSLT IN UNCON &
POSS DEATH. HDCH, DIZZ, NAUS & LOSS OF COORDINATION ARE INDICATIONS
OF EXCESS EXPOS TO VAPS/SPR AY MISTS. REDNESS & ITCH/BURN
SENSATIONMAY INDICATE EYE/EXCESS SKIN EXPOS. INTENTIONAL MISUSE BY
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:DELIB CONC & INHAL CONTENTS CAN BE
HARMFUL/FATAL. CHRONIC: TOLUENE APPEARS ON NAVY LIST OF OCCUP CHEM
REPRO HAZ. SEEK CONSULTATION FROM APPROP HLTH PROFESSIONALS
CONCERNING LATEST HAZ LIST IN FO & SAFE HNDLG & EXPOS INFO . PRLNG
OVEREXP TO LISTED SOLV INGREDS MAY CAUSE ADVERSE EFTS TO LIVER,
(ING 10)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.

First Aid:INHAL: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP & WATER.
REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE. EYES: FLUSH
EYES WITH LAR GE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTENTION. INGEST: GET MEDICAL ATTENTION.

Flash Point Method:PMCC
Flash Point:<0F,<-18C
Lower Limits:0.9%
Upper Limits:13.1%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER SPRAY MAY BE INEFTIVE. IF WATER IS USED, FOG NOZZ ARE PREF.
WATER MAY BE USED TO COOL CLSD (SUPDAT)
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, ELEC EQUIP, SPK & OPEN
FLAME. CLSD CNTNRS MAY EXPLODE WHEN EXPOS TO EXTREME HEAT.
APPLICATN TO HOT SURFS REQS SPEC PRECS. DURING (SUPDAT)

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABOSRBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPK & OPEN FLAME.
VAPS WILL ACCUM READILY & MAY IGNITE EXPLO. DURING USE & UNTIL ALL
VAPS ARE GONE:KEEP AREAS VENT. DO (ING 13)
Other Precautions:USE ONLY W/ADEQ VENT. AVOID BRTHG VAP & SPRAY MIST.
AVOID CNTCT W/SKIN & EYES. COATING MAY CNTN MATLS CLASSIFIED AS
NUISANCE PARTICULATES WHICH MAY BE PRESENT AT HAZ LEVELS ONLY
DURING SANDING/ABRADIN G OF DRIED FILM. IF NO SPECIFIC (ING 17)

Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMS BY VENT, WEAR PROPERLY FITTED ORG VAP/PARTICULATE RESP
APPRVD BY NIOSH/MSHA. WHEN SANDING/ABRADING DRIED FILM, WEAR
DUST/MIST RESP APPRVD BY NI OSH/MSHA FOR DUST WHICH MAY (ING 19)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS TO MATLS
MAINTAINED BELOW APPLIC LIMS. REFER TO OSHA STDS 1910.94,107,108.
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO: TOUCH UP SPRAY COLORS. FIRE FIGHT PROC:
CNTNRS TO PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN EXPOSED
TO EXTREME HEAT. EXPLO HAZ: EMER CNDTNS OVEREXP TO DECOMP PRODS MAY
CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED APPARENT. OBTAIN MED ATTN.

Boiling Pt:B.P. Text:<0F,<-18C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS LISTED IN INGREDIENTS.

Waste Disposal Methods:WASTE FROM PROD MAY BE HAZ UNDER RCRA 40 CFR
261. WASTE MUST BE TESTED FOR IGNIT TO DETERM APPLIC EPA HAZ WASTE
NUMBERS. WASTE FROM PRODS CONTAINING METHYL ETHYL KETONE MAY REQ
TESTING FOR EXTRACTABIL ITY. DO NOT INCIN. DEPRESSURIZE CNTNR. (ING
12)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.